150w trv-150 series switch mode led drivers constant voltage aluminum housing electrical specifcations input voltage range: 100 - 277 nom. vac (90 - 305 v min/max) frequency: 50/60 hz nom. (47-63 hz min/max) power factor: 0.90 @ 75-100% load, 100-277v thd: <_ 20% @ 75-100% load, 100-277v inrush current: 65 amps maximum @ 230 vac, cold start 25oc input current: 1.75 a max 100vac, 0.8 a max 220vac maximum power: 150w line regulation: 1% load regulation: 2% leakage current: 1 ma 277 vac 60hz typical effciency 92.5%-93.5% at 220vac turn-on delay: 0.9s typical 110vac, 0.5s typical 220vac ripple and noise: 2% v o protection: over-voltage (latch mode), over-temperature (110c), over-current (hiccup mode), lightning, and short circuit protection with self recovery environmental specifcations minimum starting temp: -35oc maximum case temp. 90c storage temperature: -40oc to +85oc humidity: 5% to 100% cooling: convection sound rating: class a mtbf: 260,000 hours @ 110vac input, 80% load and 25oc ambient conditions per mil-hdbk-217f lifetime: 77,200 hours @ 220vac, 80% load and tc=60oc weight: 2.2 lbs. (1.0 kg) model number output voltage (vdc 5%) output current range (ma) max. output power (w) typical effciency trv-150s012st 12 0-12.5 150 92% TRV-150S020ST 20 0-7.50 150 92% trv-150s024st 24 0-6.25 150 93% trv-150s036st 36 0-4.17 150 93% trv-150s048st 48 0-3.13 150 93% trv-150s054st 54 0-2.78 150 93% e332160 safety and emc compliance ul/cul ul8750, compliance to ul1012, ul935, can/csa-c22.2 no. 0, csa-c22.2 no. 107.1-01, csa-c22.2 no. 250.0 c e en 61347-1, en61347-2-13 en 55015 conducted emission test & radiated emission test en 61000-3-2 harmonic current emissions en 61000-3-3 voltage fuctuations & ficker en 61000-4-2 electrostatic discharge (esd): 8 kv air discharge, 4 kv contact discharge en 61000-4-3 radio-frequency electromagnetic field susceptibility test-rs en 61000-4-4 electrical fast transient / burst-eft en 61000-4-5 surge immunity test: ac power line: line to line 4 kv, line to earth 6 kv en 61000-4-6 conducted radio frequency disturbances test-cs en 61000-4-8 power frequency magnetic field test en 61000-4-11 voltage dips en 61547 electromagnetic immunity requirements applies to lighting equipment ? total power: 150 watts ? input voltage: 100-277 vac nom. ? ul dry & damp location rated ? ip67 ? ultra-high effciency ? high power factor ? ul8750 rev 8-28-15 h i - p o t test n o r m a l application nut me t al lock sheet the new design of this led driver provides 1.4kv surge protection. to properly hi-pot test this unit, the surge protection must be disconnected. the screw, nut, and metal lock sheet on the input side of the driver provide for this. to test, first remove the nut and lock sheet as shown. after testing, secure the nut and lock sheet to provide line-to-earth protection. this hi-pot test feature is available on product manufactured after august 15, 2015. n e w surge protection and hi-pot testing specifcations subject to change without notice. note: led drivers are designed and intended to operate led loads only. non-led loading may be outside the specifed design limits of our led drivers, and therefore cannot be covered by any warranty. if you desire to use our led drivers to operate non-led loads please contact us to discuss compatibility. thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com
pg 2 of 2 derating curve derating curve 0 -35 -20 -5 10 25 40 55 70 90 120 150 180 210 240 270 300 330 2 0 4 0 6 0 8 0 100 a m b i e n t t e m per a t u r e ( c ) load ( % ) 0 2 0 4 0 6 0 8 0 1 0 0 i n p u t v o l t a g e ( v ) load ( % ) output red (+) black (-) input black (l) white (n) green (gnd) wire specs: ac input: ul sjtw #18awg dc output: ul sjtw #18awg trv-150s012st : note, two dc output cables are connected in parallel internally, because one awg #18 wire can only carry 10a. in application, connect the two red wires together and two black wires together, or ensure that each cable carries same current. 226 199 195 209 8 213 39.5 39.5 50 34 5 5 25 67.5 503 65020 22020 ? 7.80.2 ? 7.30.2 152 503 152 output red (+) black (-) input black (l) white (n) green (gnd) 226 199 195 209 8 213 39.5 39.5 50 34 5 5 25 67.5 20 503 65020 22020 ? 7.80.2 ? 7.30.2 152 503 152 tc = 90 c max 125 20.6 tc = 90 c max 125 20.6 case temperature (c) lifetime (khrs) lifetime / case temperature 30 0 15 30 45 60 75 120 135 90 105 40 50 60 70 80 90 trv-150 series thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com ssl solutions faster than the speed of light ?
|
